Thermal insulation board_Shanghai Ciye New Energy Material Co., Ltd

Thermal insulation board

All categories

1, products and company profiles
Product Name: Nano - porous insulation board
Manufacturer: Shanghai Yipye New Energy Material Technology Co., Ltd
Address: Room 405, Building D, Jinhong Industrial Park, No.55, Luojin Road, Minhang District, Shanghai
Tel: 021-24970289
Fax: 021-24282368
Email: michael_chen307@126.com

2, harm and determine
Fibrous reinforcement compositions can cause skin, eye, throat irritation. Amorphous silica has a drying effect on the skin.
As with all other dusts, dust produced by nanoporous insulation boards exacerbates existing upper respiratory and pulmonary diseases.

3, products and ingredients

Name	CAS	EINECS	%
Amorphous silica	112945-52-5	231-545-4	50 到90%
Silicon carbide	409-21-2	206-991-8	5-50%
glass fiber	1343-98-2	215-683-2	1-10%
Alumina	1344-28-1	215-691-6	0-20%
Micro-silica fume	69012-64-2	273-761-1	0-20%

This nanoporous insulation board does not contain respirable fibers (see Section 11) and is therefore not subject to EC Directive 97/69 / EC.
The nanoporous insulation board can also be enclosed in a glass fiber woven fabric, a heat shrinkable plastic film and an aluminum-plastic composite film.

4, emergency rescue measures

Transfer the affected person to the fresh air. If the situation persists, consult a doctor immediately.Immediately rinse with plenty of water if the situation persists in a timely manner for medical treatment

Inhalation	symptom	Stimulation of the throat and nose, in extreme cases, congestion occurs
	emergency procedures
skin contact	symptom	Temporary irritation and rash
	emergency procedures	Infected parts of the water rinse, do not grab around and friction, such as the situation continued in a timely manner for medical treatment
eye contact	symptom	Short-term stimulation and inflammation
	emergency procedures
Ingestion	symptom	unknown
	Measures	If you feel that there is a problem, please seek medical attention promptly

5, fire prevention measures
Nano-porous insulation board in accordance with the vast majority of test standard test, are non-combustible materials. (Not including packaging materials)

6, the accident to take measures
Personal protection When the dust level is high, use the results of the approved protective equipment
Cleaning methods Powder and debris clean up to avoid dust in the workplace, recommend the use of vacuum cleaners and exhaust filter device is small enough to collect dust.

7, operation and storage
The operation of the nanoporous insulation board does not produce a large amount of dust released in the air. However, if the nanopore insulation board must be machined, cut, shattered or removed from the equipment, etc., and control of personal exposure to dust only by engineering means, it is necessary to wear the results of approved respirators and eyes defensive equipment.
Storage The nanoporous insulation shall be stored in a dry environment

8, exposure control and personal precautions
Engineering means: engineering control means, such as the working point of the dust is necessary to control the dust at the lowest level
Occupational Exposure Limit: The UK Department of Health and Safety issued the EH 40/02 Occupational Exposure Limits 2002

material	Total inhalable dust	Inhalation of dust
material	8小时加权平均参考期（职业暴露标准）
无定型二氧化硅	6 mg/m3	2.4 mg/m3
碳化硅	10 mg/m3	4mg/m3
氧化铝	10 mg/m3	4 mg/m3

材料

8小时加权平均参考期（最大暴露标准）

人造矿物纤维

5 mg/m3 或2纤维/ml

注：连续玻璃长丝纤维计数是不可能会达到极限。

德国“MAK 和BAT值目录 2003” 工作场所的最大浓度为：

无定型二氧化硅：4 mg/m3 可吸入粉尘

碳化硅： 1. 5 mg/m3吸入粉尘

氧化铝：1. 5 mg/m3吸入粉尘

人造矿物纤维： 0.5纤维/ml

个人防范装备：在工程手段不能充分保证粉尘受控，或有刺激的问题产生时，可能需要以下防护装置

呼吸道防护：呼吸罩和其他防护措施

手部防护：手套、润湿膏可预防手部与二氧化硅接触引起的干燥

眼睛防护：带护目镜或备有测护板的安全眼镜

皮肤防护：颈部和手腕部宽松的工作服

9、物理和化学性质

外貌：灰色

PH值：4-5（40g/L水悬浮液）

熔点：〉1700℃ （二氧化硅）

可燃性：不燃

易爆性：不爆

蒸汽压强：无

可溶性：无

气味：无

沸点：无

燃点：无

自燃：无

氧化性：无

相对密度：0.1-0.5g/ml

分配系数：无

10、稳定性和反应性

包装材料：应用到纳米微孔绝热板玻璃纤维布、其他涂层和粘结剂中的有机成分，当温度上升到150摄氏度会分解一氧化碳会释放同时还有甲醛和其他有机成分。

芯材：在所推荐使用的温度以下，纳米微孔绝热板是非常热稳定的。

11、毒物学

没有所知的毒害影响，除了对皮肤、眼睛和上呼吸道的刺激会发生。

注：纳米微孔绝热板所含细丝直径在6-11微米范围内，按照世界卫生组织的定义不含可吸入纤维。

12、生态学

纳米微孔绝热板是惰性的材料，在一定时间内稳定性高。没有这类产品的生态毒性研究。

13、处理方法

废料处理废弃的纳米微孔绝热板（即使是超过推荐使用温度的）不属于有害废物，一般来讲可以在许可的普通工业垃圾填埋场进行处理。

如果纳米微孔绝热板被其他产品所污染，有可能需要被划分为有害垃圾，请寻求专业性指导。

14、运输

无需特殊预防措施

15、法规信息